Emergency Phone Number: (510) 832-4404
Prepared: 03-01-1986
Updated: 06-01-1996
|
I. Product Identification
Generic ID: Complex Solvent Blend
DOT Shipping Name: Compounds, Cleaning, Liquid (Naphtha Solvent)
DOT Hazard Class: Flammable Liquid, NA1993
Trade Name: Dupli-Clean Super
|
II. Hazardous Components
| Ingredient |
CAS Number |
PEL(ppm) |
TLV(ppm) |
| Aliphatic Petroleum Distillates |
64742-89-8 |
500 |
300 |
| Aromatic Petroleum Distillates |
64742-95-6 |
100 |
- |
| Xylene |
1330-20-7 |
100 |
100 |
|
III. Physical Data
Boiling Point: 240° F
Specific Gravity: Less Than Water
Vapor Density (mmHg at 20° C): 15
Percent Volatiles: 100%
Evaporation Rate (Ethyl Ether=1): < 1
Specific Vapor Density (Air=1): > 1
Volatile Organic Content (VOC): 812 g/l or 6.76 lb/gal
|
IV. Fire and Explosion Data
Flash Point (TCC): < 73° F
Lower Explosive Limit: 1%
Extinguishing Media: Foam, Water Fog, Carbon Dioxide, Dry Chemical.
Special Firefighting Procedures: ; Wear self contained breathing aparatus with a full facepiece. Keep containers cool with water spray.
Unusual Fire and Explosion Hazards: Vapors are heavier than air and may travel along floor to ignition source.
|
V. Health Hazard Data
Effects of Acute Overexposure:
Eyes: Can cause irritation, redness, tearing, blurred vision.
Skin: Can cause irritation, defatting, dermatitis.
Inhalation: Can cause irritation, dizziness, weakness, fatigue, nausea, headache, possible unconsciousness or asphyxiation.
Swallowing: Can cause gastrointestinal irritation, nausea, vomiting and diarrhea.
First Aid:
Eyes: Flush with water lifting upper and lower lids. Get medical attention.
Skin: Wash exposed area with soap and water.
Inhaled: Remove to fresh air. Give oxygen or artificial respiration as required. Get medical attention.
Swallowed: DO NOT induce vomiting. Get medical attention.
Chronic Effects of Overexposure:
Cardiovascular stress. May affect liver, kidneys and respiratory system.
|
VI. Reactivity Data
Hazardous Polymerization: Will not occur.
Stability: Stable.
Incompatibility (Avoid Contact With): Strong oxidizing agents.
|
VII. Spill or Leak Procedures
Spill Procedures: Eliminate all ignition sources. Clean with absorbent materials and place in closed containers for waste disposal.
Waste Disposal: Consult Federal, State and Local disposal authorities for approved disposal procedures.
|
VIII. Special Protection and Precautions
Respiratory Protection: Approved organic vapor type respirator if TLV (or PEL) values are exceeded.
Ventilation: Provide ventilation to maintain safe exposure levels.
Protective Gloves: Wear resistant gloves such as: Nitrile rubber.
Eye Protection: Chemical splash goggles in compliance with OSHA regulations.
Other Protective Equipment: Wear impervious clothing if desired.
|
|
Comments: Containers of this material may be hazardous when empty. Since empty containers retain product residues (vapor, liquid and/or solid), all hazard precautions in this datasheet must be observed. |
