Material Safety Data Sheet
Emergency Phone Number: (510) 832-4404
Prepared: 04-01-1991
Updated: 06-01-1996
|
I. Product Identification
Generic ID: Complex Solvent Blend
DOT Shipping Name: Oil, N.O.S.
DOT Hazard Class: Combustible Liquid, NA1270
Trade Name: DCB - 2000 Press Wash
|
II. Hazardous Components
| Ingredient | CAS Number | PEL(ppm) | TLV(ppm) |
| 4-isopropenyl | 5989-27-5 | - | - |
| 1-methylcyclohexane | 8008-57-9 | - | - |
|
III. Physical Data
Boiling Point: > 300° F
Specific Gravity: Less Than Water
Vapor Density (mmHg at 20° C): 2
Evaporation Rate (Ethyl Ether=1): Slower Than Ether
Specific Vapor Density (Air=1): >1
Volatile Organic Content (VOC): 840 g/l or 7.00 lb/gal
|
IV. Fire and Explosion Data
Flash Point (TCC): > 100° F
Lower Explosive Limit: > 0.7%
Extinguishing Media: Foam, Water Fog, Carbon Dioxide, Dry Chemical.
Special Firefighting Procedures: Wear self contained breathing aparatus with a full facepiece. DO NOT use water; handle as an oil fire Class B fire procedures.
Unusual Fire and Explosion Hazards: Vapors are heavier than air and may travel along floor to ignition source.
|
V. Health Hazard Data
Effects of Overexposure:
Eyes: Can cause irritation.
Skin: Can cause irritation.
Inhalation: Can cause irritation.
Swallowing: Can cause gastrointestinal irritation, nausea, vomiting and diarrhea.
First Aid:
Eyes: Flush with water lifting upper and lower lids. If irritation persists, get medical attention.
Skin: Wash exposed area with soap and water.
Inhaled: Remove to fresh air. Give oxygen or artificial respiration as required.
Swallowed: Get medical attention.
Chronic Effects of Overexposure:
None Known.
|
VI. Reactivity Data
Hazardous Polymerization: Will not occur.
Stability: Stable.
Incompatibility (Avoid Contact With): Strong oxidizing and acidic agents.
|
VII. Spill or Leak Procedures
Spill Procedures: Eliminate all ignition sources. Clean with absorbent materials and place in closed containers for waste disposal.
Waste Disposal: Consult Federal, State and Local disposal authorities for approved disposal procedures.
|
VIII. Special Protection and Precautions
Respiratory Protection: Not normally required, but if vapor concentration becomes high, use self contained breathing apparatus.
Ventilation: Provide ventilation to maintain safe exposure levels.
Protective Gloves: Wear resistant gloves such as: Nitrile rubber.
Eye Protection: Chemical splash goggles in compliance with OSHA regulations.
Other Protective Equipment: Usually not needed.
|
|
Comments: Containers of this material may be hazardous when empty. Since empty containers retain product residues (vapor, liquid and/or solid), all hazard precautions in this datasheet must be observed. |
